Product ID:WALKWAY TYPE I LIGHT GULL GRAY, G-8605
MSDS Date:02/04/1999
FSC:8010
NIIN:00-141-7842
Status Code:A
MSDS Number: CLNNR

AKRON PAINT AND VARNISH INC

1390 FIRESTONE PARKWAY
AKRON, OH 44301-1624
US

Emergency Phone: 330-773-8911

Info Phone: 216-773-8911

Preparer: ERNEST CARTER

Cage: 70228

AKRON PAINT AND VARNISH INC

AKRON, OH 44301-1624 US

Telephone: 216-773-8911

Cage: 70228

VM&P NAPHTHA

CAS: 64742-89-8

OSHA PEL 300 PPM

ACGIH TLV: 300 PPM

XYLENE

CAS: 1330-20-7

RTECS: ZE2100000

OSHA PEL 100 PPM

ACGIH TLV: 434 MG/M3;100 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

Effects of Overexposure:EYES: CAN CAUSE REDNESS, IRRITATION, SWELLING
AND BLURRED VISION. SKIN: PROLONGED OR REPEATED CONTACT CAN CAUSE
MODERATE IRRITATION, DEFATTING, DERMATITIS. BREATHING: CAN CAUSE
RESPIRATORY IRRITATION , DIZZINESS, WEAKNESS, FATIGUE NAUSEA,
HEADACHE, UNCONSCIOUSNESS.AND EVEN ASPHYXIATION.SWALLOWING: CAN
CAUSE GASTROINTESTINAL IRRITATION, NAUSEA, VOMITING AND DIARRHEA;
ASPIRATION OF MATERIAL INTO THE LUNGS CAN CAUSE CHEMICAL
PNEUMONITIS WHICH CAN BE FATAL.

First Aid:EYES: FLUSH WITH LARGE AMOUNTS OF WATER FOR 15 MINUTES.LIFT
EYELIDS OCCASIONALLY, GET PROMPT MEDICAL ATTENTION.SKIN: WASH
THOROUGHLY WITH SOAP AND WATER.REMOVE CONTAMINATED CLOTHING
PROMPTLY;WASH CLOT HING BEFORE REUSE. CONSULT A PHYSICIAN IF
IRRITATION PERSISTS.SWALLOWING:SINCE THIS PRODUCT MAY CONTAIN
MATERIALS WHICH CAN CAUSE LUNG DAMAGE IF ASPIRATED INTO THE
LUNGS,THE DECISION WHETHER TO IN DUCE VOMITING MUST BE MADE BY A
PHYSICIAN AFTER CAREFUL CONSIDERATION OF ALL MATERIALS INGESTED.
INHALATION: MOVE AFFECTED PERSON TO FRESH AIR. IF BREATHING IS
DIFFICULT, ADMINISTER OXYGEN. IF BRE ATHING HAS STOPPED, GIVE
ARTIFICIAL RES

Flash Point Method:TCC
Flash Point:=10.C, 50.F
Lower Limits:0.90%
Upper Limits:12.30%
Extinguishing Media:CARBON DIOXIDE DRY CHEMICAL FOAM WATER FOG. USE
WATER FOR COOLING MATERIAL STORED IN VICINITY OF FIRE.
Fire Fighting Procedures:USE SELF-CONTAINED BREATHING APPARATUS WITH A
FULL FACEPIECE OPERATED IN PRESSURE-DEMAND OR OTHER POSITIVE
PRESSURE MODE. WEAR PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR AND MAY
TRAVEL ALONG THE GROUND TO AN IGNITION SOURCE SOME DISTANCE FROM
MATERIAL HANDLING OINT. IGNITION SOURCES INCLUDE PILOT LIGHTS,
SMOKING, HEATERS, ELECTRIC MOTORS, S PARKS FROM ELECTRICAL SWITCHES
AND STATIC DISCHARGES.NEVER USE CUTTING TORCH ON EMPTY CONTAINERS!

Spill Release Procedures:SMALL SPILL: ABSORB LIQUID WITH RAGS, FLOOR
ABSORBENT, VERMICULITE OR OTHER ABSORBENT MATERIAL AND TRANSFER TO
HOOD. LARGE SPILL: ELIMINATE ALL IGNITION SOURCES DIKE AREA OF
SPILL TO PREVENT SPREADING . VENTILATE AREA IF INDOORS PUMP LIQUID
INTO SALVAGE TANK REMAINING LIQUID MAY BE TAKEN UP WITH SAND, FLOOR
ABSORBENT OR OTHER ABSORBENT MATERIAL AND SHOVELED INTO CONTAINERS
PREVENT RUN OFF TO SEWERS

Handling and Storage Precautions:DO NOT DROP CONTAINERS. AVOID HEAT,
SPARKS, AND OPEN FLAME. STORE LARGE QUANTITIES ONLY IN BUILDINGS
DESIGNED TO COMPLY WITH OSHA 1910.106. NEVER USE PRESSURE TO EMPTY.
AVOID BREATHING SANDING DUST.DO NOT HANDLE UNTIL THE MANUFACTURERS
SAFETY PRECAUTIONS HAVE BEEN READ AND UNDERSTOOD.
Other Precautions:THE INFORMATION ACCUMULATED HEREIN IS BELIEVED TO BE
ACCURATE BUT IS NOT WARRANTED TO BE ORIGINATING WITH THE COMPANY OR
NOT.RECIPIENTS ARE ADVISED TO CONFIRM IN ADVANCE OF NEED THAT THE
INFORMATION I S CURRENT, APPLICABLE, AND SUITABLE TO THEIR
CIRCUMSTANCES.

Respiratory Protection:IN OUTDOOR OR OPEN AREAS WITH UNRESTRICTED
VENTILATION APPROVED CHEMICAL/MECHANICAL FILTERS DESIGNED TO REMOVE
A COMBINATION OF PARTICULATES AND VAPOR. IN CONFINED AREAS,
APPROVED AIR LINE TYPE RESPIR ATORS OR HOODS.
Ventilation:PROVIDE SUFFICIENT VENTILATION IN VOLUME AND PATTERN TO
KEEP AIR CONTAMINANT CONC BELOW CURRENT OSHA PEL OR ACGIH TLV
LIMITS, VOLATILES BELOW VOLATILE LIMIT.
Protective Gloves:WEAR RESISTANT GLOVES SUCH AS NITRILE RUBBER.
Eye Protection:CHEMICAL SPLASH GOGGLES. ARE SAFETY GLASSES.
Other Protective Equipment:NORMAL PROTECTIVE CLOTHING.
Supplemental Safety and Health

Boiling Pt:B.P. Text:240-289 DEG F
Vapor Density:HEAVIER
Spec Gravity:1.27011
Evaporation Rate & Reference:6.5 X N-BUTYL ACETATE
Appearance and Odor:LT GULL GRAY
Percent Volatiles by Volume:54.1%

Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZERS. ( LIKE NITRIC ACID)
Stability Condition to Avoid:KEEP AWAY FROM HEAT AND OPEN FLAME.
Hazardous Decomposition Products:MAY FORM CARBON MONOXIDE AND DIOXIDE,
VARIOUS HYDROCARBONS, ETC.
Conditions to Avoid Polymerization:WILL NOT OCCUR.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE AND
LOCAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

State Regulatory Information: